Your browser does not support JavaScript
(317) 440-9102   
  2243 Massachusetts Ave
Indianapolis, Indiana 46218
www.circlecitycryogenics.com 
 
      

Brake Rotors - www.circlecitycryo.com - Circle City Cryogenics

BRAKE ROTORS

 

Brake Rotors & Drums

 

By using cryogenics on rotors, braking mechanisms last longer and provide better quality, saving money and time.

  • Reduced Wear and Distortion
  • Increased relief and stability
  • Significantly increases wear life up to 3x
   
There are also improvements after freezing plastic. Just about anything with metal can be cryogenically treated, guitar strings, razors and gun barrels, as well as large machinery parts.Your parts only need treated once. We can lower your operating and maintenance cost. We do this for many individuals also.

Brake Rotor Tests

The following are brake tests being conducted on vehicles using brake rotors that have been Cryogenic treated. Each test has already been successful even though the pads and the treated rotors continued to operate and had much more life remaining in them. The tests involve vehicles used in motor sports, ambulances, busses, and police cars. These gave us a very good cross section to show the advantages of the Cryogenic treatment and it’s results.

TEST #1 AMBULANCE

Before using Cryogenic treated brake rotors, the Decatur “In Town” ambulance service had been replacing brake pads every 5000 miles or every two months. They had been replacing the brake rotors every 18,000 miles due to warpage and cracking. After Cryogenic treatment of the brake rotors they were able to run them for ten months, a 400%increase in pad life and a 140% gain in rotor life with both still in operation.

TEST #2 BUS FOR THE HANDICAPPED

Before using treated rotors on specially constructed FORD E-350 vans (ordered from FORD with 7.3 diesel engines and 4 wheel drive by the bus manufacturer. The rear drive shaft removed and the bus operated as a front wheel drive so that a large body is mounted very low for wheel chair access.) the brake pads on these special built buses had to be replaced at 2500 miles. After the Cryogenic treatment to a new set of rotors with new pads installed, the bus now has 9000 miles with the same rotors and pads.

TEST #3 POLICE CAR

At a police training school where police are professionally trained for high speed pursuit on road courses, speeds reached and the abuse involved caused performance tires and brake rotors to be replaced at 400 miles. The rotors would warp and crack causing brake fade. New brake pads and cryogenically treated rotors were installed on the squad cars. After 1200 miles, the rotors are still running with no signs of warpage or cracking. The officers continue to remark that the brakes feel better and don’t fade like in the past.

TEST #4 RACE CAR

A stock production race car running at the Portland International Raceway road course had a very good aggressive driver that continually wore out his brake pads before the race was over. Treated rotors were installed for the next race and after the race was over there was still 40% of the pads left. Now this allows them to use race pads for the next practice and qualifying session and then install new pads for the race. They can then continue to use the same rotors each race.
 
1 of 4
 
Dudley Taylor,  Battalion Chief of the Indianapolis Fire Department
 

The implementation of the use of Cryogenics is a NO BRAINER, THE RESULTS ARE TRULY AMAZING. If you have a fleet of vehicles, a machine shop, or the need to increase the longevity of your equipment and save thousands of dollars, this is your answer!” 

   Dudley Taylor,  Battalion Chief of the Indianapolis Fire Department

 

     
 
TERMS  PRIVACY POLICY  
     


COPYRIGHT 2018. CIRCLE CITY CRYOGENICS. ALL RIGHTS RESERVED. 
WARNING: SOME PLASTICS MAY CRACK OR BREAK AND SHOULD BE REMOVED BY CUSTOMER PRIOR TO SUBMITTING FOR TREATMENT. CUSTOMER ASSUMES ALL RISKS OTHERWISE. 

Facebook - Circle City Cryogenics